Environment skill
 |
It's easier to work to make the angle pouring out big circle or small circle when you are bottoming。 |
 |
It's absolutely helpful for the quality of construction and the afterward warrant and pay attention to the moisture content(RC hydrous quantity) of the wall before construction. |
| |
 |
The applying introduction for the process of construction and the building skill The constructional detail about the cleaning marble without water：
|
|
Using the toothlike part of toothlike spatula smear over the slurry average, then flatten slurry by anther side to make the cement flat on the wall and paste marbles. Finally, using a spongy spatula make slurry to float until slurry over reticulate |
|
It must put carefully and softly to avoid the marble's surface to touch slurry. The master worker can clean the marble by a soft brush and wipe it cleanly by a spongy if the marble touches the slurry. |
 |
It must pay attention to the marble's thickness when the master worker use the spatula (It is different for the marble's thickness). Please the master worker use different toothlike spatulas to avoid waste slurry or make slurry insufficient. |
| |
 |
The material characteristic
|
| |
 |
The purpose:
For a right angle or suppress side plank | |
 |
The purpose:
For a belt or a beam belt | |
|
The purpose:
The skill of straight line pasting marbles | |
|
The purpose:
The skill without seam | | |
The specifications of the product
|
The way to wipe the seam on that day or next day
|
|
The way to wipe the seam on that day：Please wipe seam after the cement shrink to clot slightly. It's easier to work and the probability that marbles bind upward will be lower, and press marbles down by a harder spatula if marbles float up. |
|
The way to wipe the seam on the next day：Please wipe the seam carefully to result in the slurry floating too much. If slurry float on surface, it have to brush the surface of the seam deep to avoid appearing two color in the seam. |
The skill of using the wiping seam sponge rub marbles
|
|
Be take care of the percentage of water and slurry for wiping seam. The consistency should not be too high（too diluted） to make the seam bubbling because of absorbing water too much. |
|
To avoid marbles show bad mixed color and luster or personal equation, it had better to use the special filling materials in wiping seam. |
|
To plaster slurry by a spongy spatula when you wipe seam. After slurry shrinks slightly, scrape the seam smooth and clean it by a spongy spatula from almost vertical angle. Then mop the marble by a square spatula and remember to change the washing water. Finally, it's better to mop the square slowly, and it will not clean completely because of mopping too fast or using too old and shabby square. |
The skill of remaining side in ending
|
|
To add the slurry's thickness in the ending while working in remaining side, and slurry could cover marbles completely. |
|
The time of using keeping fit paster (like silicon's paster) is that start to wok before slurry shirk and it will paste easier. After cleaning it on that day and ripping it to avoid it so sticky that you can't rip it easily. Never rip it on the next day.
|
The skill of staying seam in advance
|
| |
When you must work dividedly because of a bigger area or longer working time, you must stay seam in advance. At this time, the bottom layer's slurry could not be higher than the net. The slurry must leave three to five centimeters from the stern of the net, and connect marbles after pulling slurry high and wiping slurry on the next working day. By this way, it can avoid the height of the seam could not smooth and have different height.
|
The skill of staying seam in advance or without seam
|
|
Staying seam：The skill of pasting marbles stayed seam in advance is the same with the skill of pasting marbles , and have not to suppress plank. The skill also is the most fast and could retrench working time and has more variations. |
| |
For example:
|
 |
|
|
The skill without seam：It must work one piece next to one piece. The best advantage of the skill could show the continuous quality of stone carpet, and it will have the identical feeling. The other material could not show these qualities. |
The matters concerned on the pavement and the lane
|
|
The best time of constructing pavement and the lane, it is better to paste marbles after finishing bottoming on the next day or in short-term. After pasting marbles, it is better to wipe seam on that day to avoid fine sands and filths filled up the seam because of delayed time, and you could not deal well.
|
|
The skidproof effect is better because of using more thickness stone material on the lane. |
The advantage of the skill for economizing the use of energy resources
|
|
It can economize half of slurry more than traditional skill.
|
|
It will lower managerial and sales cost if you use the skill for long time.
|
|
It can lower the pollution at working place.
|
 |
You can control the rate of progress, and shorten working time. |
 |
The skidproof effect is higher on the pavement and the lane.
|
 |
The designer can collocate to work according to his designing ideas.
|
 |
It is easier to work to decorate the indoor wall's planks. | |
 |
|
